Families of Marines killed in 2022 Osprey crash file lawsuit against the aircraft's manufacturers

Families of Marines killed in 2022 Osprey crash file lawsuit against the aircraft's manufacturers

Families of Marines killed in 2022 Osprey crash file lawsuit against the aircraft's manufacturers

Families of four of the five Marines killed when their Osprey crashed in California in June of 2022 have filed a federal lawsuit alleging that the aircraft's manufacturers failed to address known mechanical failures that led to the deaths

ByTARA COPP Associated Press

May 23, 2024, 6:28 PM

    WASHINGTON -- Families of four of the five Marines killed when their Osprey crashed in California in June of 2022 filed a federal lawsuit Thursday alleging that the aircraft's manufacturers failed to address known mechanical failures that led to the deaths.

    The Marines were killed when their MV-22 Osprey experienced a catastrophic mechanical failure known as hard-clutch engagement, a known problem with the tilt-rotor aircraft that has happened more than a dozen times since 2010.

    The families named Bell Textron, The Boeing Co. and Rolls Royce in their lawsuit. Bell assembles the Osprey in a partnership with Boeing in its facilities in Amarillo, Texas; Rolls Royce produces the Osprey’s engines.

    The Osprey can take off or land like a helicopter but fly like an airplane. The military services have called it a game-changer in that it allows them to travel long distances quickly and land on a target, but it has not been without significant cost: More than 50 service members have been killed in accidents since 2000 in the aircraft.

    The lawsuit alleges that the Osprey’s design was flawed and did not meet U.S. safety standards.

    The Osprey’s two engines are linked by an interconnected drive shaft that runs inside the length of the wings. On each tip, by the engines, a component called a sprag clutch transfers torque, or power, from one proprotor to the other to make sure both rotors are spinning at the same speed. That keeps the Osprey’s flight in balance. If one of the two engines fails, the sprag clutch is also a safety feature: It will transfer power from the working side to the failing engine’s side to keep both rotors going.

    When a worn clutch slips, a hard-clutch engagement can occur as the system rapidly re-engages. This creates a power spike that surges power to the other engine and can throw the Osprey into an uncontrolled roll or slide, which can cause catastrophic loss of control, leaving pilots only seconds to save their aircraft or crew.

    The investigation into the 2022 crash concluded that the Marines were doing routine flight operations when they experienced a dual hard-clutch engagement, leading to a “catastrophic, unpreventable and unanticipated mechanical failure."

    There were no steps the pilots could have taken to prevent it and “no means of recovery once the compound emergency commenced," the Marines' 400-page report said.

    The Osprey crashed in a remote area near Glamis, about 115 miles (185 kilometers) east of San Diego.

    Five Marines died in the crash: two pilots, Capt. Nicholas P. Losapio, 31, of Rockingham, New Hampshire, and Capt. John J. Sax, 33, of Placer, California; and three crew chiefs, Cpl. Nathan E. Carlson, 21, of Winnebago, Illinois, Cpl. Seth D. Rasmuson, 21, of Johnson, Wyoming, and Lance Cpl. Evan A. Strickland, 19, of Valencia, New Mexico.

    As the Air Force, Navy and Marine Corps had begun looking at the problem following multiple incidents in 2022, including the fatal crash, they determined that the clutches may be wearing out faster than anticipated. The Osprey program is working on a redesign for a component that mitigates clutch slippage.

    In its 2022 report, the Marine Corps warned that more accidents were possible because neither the military nor the manufacturers have been able to isolate a root cause. It said future incidents were “impossible to prevent without improvements to flight control system software, drivetrain component material strength, and robust inspection requirements.”

    The lawsuit comes as families await results from investigations into two deadly Osprey crashes last year. In August of 2023, three Marines were killed in an Osprey crash off of Australia, and eight U.S. Air Force Special Operations service members were killed in November 2023 when their Osprey crashed off the coast of Japan. The Air Force took the unusual step of quickly identifying a materiel failure as a potential cause of that crash, and a week after the crash all of the services had grounded the Osprey fleet. The ban on flights was lifted three months later.

    Boeing and Bell said they were unable to comment on litigation. Rolls Royce did not immediately respond to a request for comment.

    OTHER NEWS

    16 minutes ago

    Protesters in Kenya are tired of double standards, and it will take more than bullets to stand them down

    16 minutes ago

    BHP rejects hydrogen and hybrids, backs electric trucks

    16 minutes ago

    Barclays boss says calls for bank to abandon oil and gas are unrealistic

    16 minutes ago

    The damning stat that proves England’s attacking play is slowest at Euro 2024

    16 minutes ago

    DeSantis signs bill banning balloon releases in Florida

    16 minutes ago

    Five South African pilgrims die in Saudi Arabia during the Hajj

    19 minutes ago

    Rockets reportedly seeking Kevin Durant, Devin Booker or other ‘major upgrade'

    21 minutes ago

    Video: Abbie Chatfield receives a VERY personal X-rated gift for her birthday from boyfriend Adam Hyde

    23 minutes ago

    Ohtani hits a leadoff homer for the Dodgers to extend RBI streak to a career-high 9 games

    23 minutes ago

    Donald Trump free to criticise Stormy Daniels in TV debate

    23 minutes ago

    President of the Republic calls for provision of necessary funds to repair buses, trains and metro cars

    23 minutes ago

    Inflation rises to 4% stoking concern interest rates could increase again

    23 minutes ago

    India’s Prime Minister Modi to visit Russia, says Kremlin

    23 minutes ago

    The best air fryer for quick and easy meals

    23 minutes ago

    Paramount's CEOs Say Bankers Have Been Hired to Sell Assets, Talk Job Cuts in Town Hall

    26 minutes ago

    Charges filed after large fight near Mount Greenwood restaurant, Chicago police say

    28 minutes ago

    Anthony Albanese woke up this morning and chose weakness- after being betrayed by one of his own, Fatima Payman, in the most public of fashions, writes PETER VAN ONSELEN

    28 minutes ago

    Knicks acquire Mikal Bridges from Nets in stunning NBA trade

    29 minutes ago

    Trump Campaign Claims Ad Using Trump’s Own Words Could Violate KKK Act

    29 minutes ago

    Trump-backed Colorado GOP chair loses House primary

    29 minutes ago

    Living cost relief, housing top ACT's budget priorities

    29 minutes ago

    Ange Postecoglou reveals what he 'loves' about Cole Palmer after England Euro 2024 draw

    30 minutes ago

    Washington high court to decide if Seattle officers who attended Jan. 6 rally can remain anonymous

    30 minutes ago

    New York Knicks acquiring Mikal Bridges in pricey deal with Brooklyn Nets. Who won the trade?

    30 minutes ago

    Bombers coach comfortable with Danger's tribunal win

    30 minutes ago

    Australia’s economy is ‘in decline’: John Anderson

    30 minutes ago

    Archaeologists find 2,000-year-old Roman military sandals in Germany with nails for traction

    30 minutes ago

    Tarik Skubal strikes out 7 in 7 scoreless innings, Tigers beat Phillies 4-1

    30 minutes ago

    Two brand new faces spotted at Kaizer Chiefs

    30 minutes ago

    Steve McCann appointed CEO at The Star

    30 minutes ago

    Egypt electricity cuts extended, sparking outrage amid population

    30 minutes ago

    Volkswagen's $5 billion investment in Rivian boosts EV maker's shares

    30 minutes ago

    The ASX 200 just plummeted on May's inflation figures. Here's why

    32 minutes ago

    FDA warns maker of Sara Lee and Entenmann's not to claim foods contain allergens when they don't

    38 minutes ago

    Jamaal Bowman loses in the most expensive House primary in history

    38 minutes ago

    Carnival Corp raises annual profit forecast again on steady cruise demand

    38 minutes ago

    Professional Faqs: Do Beets Help With Gout?

    38 minutes ago

    AEMO report dismissing nuclear power has a 'couple' of issues: Shadow Finance Minister

    38 minutes ago

    Connor McDavid wins Conn Smythe as playoff MVP despite Oilers losing Stanley Cup Final to Panthers

    38 minutes ago

    Decode Politics: Why is the BJP talking of Emergency again?